LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Ford >> 2015 >> Explorer Limited, 3.5L Eng VIN 8, AWD >> Repair and Diagnosis >> Accessories & Equipment >> Entertainment Systems >> Information And Entertainment Systems - Premium Plus >> Diagnosis And Testing >> Information and Entertainment System Premium Plus >> Pinpoint Tests >> Pinpoint Test O : The LR Door Speaker Is Inoperative Or Has Poor Sound Quality >> Pinpoint Test O : The LR Door Speaker Is Inoperative Or Has Poor Sound Quality

Pinpoint Test O : The LR Door Speaker Is Inoperative Or Has Poor Sound Quality

  1. O1 CHECK THE AUDIO SIGNAL TO THE LR DOOR SPEAKER

    • Ignition OFF.
    • Disconnect: LR Door Speaker C702 .
    • Operate the audio system in radio tuner AM/FM mode.
    • Measure:
      Positive Lead Measurement / Action Negative Lead
      C702-1
      GFD33602Courtesy of FORD MOTOR COMPANY
      		 C702-4

    Is a fluctuating AC voltage present? 

    Yes  INSTALL a new LR door speaker. Refer to Speaker - Door .
    No  GO to  O2.

  2. O2 CHECK THE AUDIO CIRCUITS TO THE LR DOOR SPEAKER FOR A SHORT TO VOLTAGE

    • Ignition OFF.
    • Disconnect: ACM C240A .
    • Disconnect: LH Quarter Panel Speaker.
    • Ignition ON.
    • Measure:
      Positive Lead Measurement / Action Negative Lead
      C702-1
      GFD33595Courtesy of FORD MOTOR COMPANY
      		 Ground
      C702-4
      GFD33595Courtesy of FORD MOTOR COMPANY
      		 Ground

    Is any voltage present? 

    Yes  REPAIR the circuit in question.
    No  GO to  O3.

  3. O3 CHECK THE AUDIO CIRCUITS TO THE LR DOOR SPEAKER FOR A SHORT TO GROUND

    • Ignition OFF.
    • Measure:
      Positive Lead Measurement / Action Negative Lead
      C702-1
      GFD33596Courtesy of FORD MOTOR COMPANY
      		 Ground
      C702-4
      GFD33596Courtesy of FORD MOTOR COMPANY
      		 Ground

    Are the resistances greater than 10, 000 ohms? 

    Yes  GO to  O4.
    No  REPAIR the circuit in question.

  4. O4 CHECK THE AUDIO CIRCUITS FOR A SHORT TOGETHER

    • Measure:
      Positive Lead Measurement / Action Negative Lead
      C702-1
      GFD33596Courtesy of FORD MOTOR COMPANY
      		 C702-4

    Is the resistance greater than 10, 000 ohms? 

    Yes  GO to  O5.
    No  REPAIR the circuits.

  5. O5 CHECK THE AUDIO CIRCUITS TO THE LR DOOR SPEAKER FOR AN OPEN

    • Measure:
      Positive Lead Measurement / Action Negative Lead
      C702-1
      GFD33596Courtesy of FORD MOTOR COMPANY
      		 C240A-21
      C702-4
      GFD33596Courtesy of FORD MOTOR COMPANY
      		 C240A-9

    Are the resistances less than 3 ohms? 

    Yes  GO to  O6.
    No  REPAIR the circuit in question.

  6. O6 CHECK FOR CORRECT ACM OPERATION

    • Ignition OFF.
    • Disconnect and inspect all ACM connectors.
    • Repair:
      • Corrosion (clean module pins or install new connectors or terminals)
      • Damaged or bent pins (install new terminals or pins)
      • Pushed-out pins (install new pins as necessary)
    • Reconnect the ACM connectors. Make sure they seat and latch correctly.
    • Operate the system and determine if the concern is still present.

    Is the concern still present? 

    Yes  CHECK OASIS for any applicable TSBs. If a TSB exists for this concern, DISCONTINUE this test and FOLLOW TSB instructions. If no TSBs address this concern, INSTALL a new ACM. Refer to Audio Control Module (ACM) .
    No  The system is operating correctly at this time. The concern may have been caused by module connections. ADDRESS the root cause of any connector or pin issues.
scientia non olet · About LEMON Manuals