Diagnostic Test
- CHECK FOR AN ACTIVE DTC
- Turn the ignition on.
- With the scan tool, read and record DTCs on the repair order.
- With the scan tool, read and record Environmental Data to help identify the conditions in which the DTC was set.
- With the scan tool, erase ABS DTCs.
- Cycle the ignition switch from off to on.
- With the scan tool, read ABS DTCs.
Did the DTC return?
Yes
- Go To 2
No
- The condition that caused the symptom is currently not present. Inspect the related wiring for a possible intermittent condition. Look for any chafed, pierced, pinched, or partially broken wires.
- Perform the ABS INTERMITTENT CONDITION TEST. Refer to ABS INTERMITTENT CONDITION .
- CHECK CONNECTOR/TERMINAL FOR DAMAGE NOTE:
Check all terminals for broken, bent, pushed out, or corroded terminals.
- Turn the ignition off.
- Inspect the Brake Pedal Travel Sensor for proper mounting.
- Inspect the Brake Pedal Travel Sensor harness and connector.
- Inspect the Anti-lock Brake System (ABS) Module harness and connector.
Were any problems found?
Yes
- Repair as necessary in accordance with the Service Information.
- Perform the ABS VERIFICATION TEST. Refer to ABS VERIFICATION TEST .
No
- Go To 3
- (B937) PEDAL TRAVEL SENSOR RETURN CIRCUIT SHORTED TO VOLTAGE
- Disconnect the ABS Module harness connector.
- Disconnect the Brake Pedal Travel Sensor harness connector.
- Turn the ignition on.
- Measure the voltage between the (B937) Pedal Travel Sensor Return circuit and ground.
Is there any voltage present?
Yes
- Repair the (B937) Pedal Travel Sensor Return circuit for a short to voltage.
- Perform the ABS VERIFICATION TEST. Refer to ABS VERIFICATION TEST .
No
- Go To 4
- (B237) PEDAL TRAVEL SENSOR FEED CIRCUIT SHORTED TO VOLTAGE
- Measure the voltage between the (B237) Pedal Travel Sensor Feed circuit and ground.
Is there any voltage present?
Yes
- Repair the (B237) Pedal Travel Sensor Feed circuit for a short to voltage.
- Perform the ABS VERIFICATION TEST. Refer to ABS VERIFICATION TEST .
No
- Go To 5
- Measure the voltage between the (B237) Pedal Travel Sensor Feed circuit and ground.
- (B237) PEDAL TRAVEL SENSOR FEED CIRCUIT SHORTED TO GROUND
- Turn the ignition off.
- Measure the resistance between the (B237) Pedal Travel Sensor Feed circuit and ground.
Is the resistance below 5.0 Ohms?
Yes
- Repair the (B237) Pedal Travel Sensor Feed circuit for a short to ground.
- Perform the ABS VERIFICATION. Refer to ABS VERIFICATION .
No
- Go To 6
- BRAKE PEDAL POSITION (BPP) SENSOR
- Turn the ignition off.
- Connect the ABS Module harness connector.
- Turn the ignition on.
- Measure the voltage at the BPP Sensor harness connector between the (B237) BPP Sensor Feed and the BPP Sensor Return.
Is the voltage above 4.8 volts?
Yes
- Replace the Brake Pedal Position (BPP) Sensor in accordance with the Service Information. Refer to SENSOR, STOP LAMP, REMOVAL AND INSTALLATION .
- Perform the ABS VERIFICATION TEST. Refer to ABS VERIFICATION TEST .
No
- Go To 7
- CHECK RELATED HARNESS CONNECTIONS
- Disconnect the ABS Module harness connector.
- Disconnect all related in-line harness connections (if equipped).
- Disconnect the related component harness connectors.
- Inspect harness connectors, component connectors, and all male and female terminals for the following conditions:
- Proper connector installation.
- Damaged connector locks.
- Corrosion.
- Other signs of water intrusion.
- Weather seal damage (if equipped).
- Bent terminals.
- Overheating due to a poor connection (terminal may be discolored due to excessive current draw).
- Terminals that have been pushed back into the connector cavity.
- Perform a terminal drag test on each connector terminal to verify proper terminal tension.
Repair any conditions that are found.
- Connect the ABS Module harness connector. Be certain that the harness connector is fully seated and the connector lock is fully engaged.
- Connect all in-line harness connectors (if equipped). Be certain that all connectors are fully seated and the connector locks are fully engaged.
- Connect the related component harness connectors. Be certain that all connectors are fully seated and the connector locks are fully engaged.
- With the scan tool, erase DTCs.WARNING:
To avoid possible serious or fatal injury, check brake capability is available before road testing.
- Using the recorded Event and Environmental Data, along with the When Monitored and Set Conditions above, operate the vehicle in the conditions that set the DTC.
- With the scan tool, read ABS Module DTCs.
Did the DTC return?
Yes
- Replace the Anti-lock Brake System (ABS) Module in accordance with the Service Information. Refer to MODULE, ANTI-LOCK BRAKE SYSTEM (ABS), REMOVAL AND INSTALLATION .
- Perform ABS VERIFICATION TEST. Refer to ABS VERIFICATION TEST .
No
- Perform ABS VERIFICATION TEST. Refer to ABS VERIFICATION TEST .
- Test complete.